Lamson Park Is Getting Turf

[31Ragin97]

BUT BUT BUT I thought we were trying to shut down the softball program. This looks like the total opposite. 😂😂😂😂😂😂😂😂😂😂😂

it does seem to feel much hotter at times on turf, is that people's experience at the tigue?

[cajun_lannister]

The concrete area you speak of is probably soil cement. A concrete slab would be prohibitively expensive and they would not have been able to do it in such short time. They may place a thin layer of limestone over the soil cement for final grading. They will then place a plastic drainage layer / padding. It looks like an egg container. It pops together like Lego blocks but its rolled out in sheets.

Once that is done they will roll out the turf and seam it together. It's glued together just like regular home carpet but the tape is wider with a different type of hot melt glue. The backing for the turf has millions of perforations to let the water through. Once the turf is down they get sheep shears and cut out the areas for lines and logos. They glue the lines and logos down with hot melt glue. That makes the lines a little bit higher than the rest of the turf. (It's the same with yard line numbers and hash marks on football fields). That's why you will see players trip on a wide open field.

Once the turf is down they place a layer of sand over the field. They brush it in til about one inch of the blade is showing. The sand is to weigh the turf down so it doesn't blow up in high winds. After the sand they spread rubber pellets over the turf and brush them in until about one quarter of an inch of the grass shows. The rubber is a cushion. The warning track will probably be a little shorter blade with not as much cushion.

If there drainage doesn't work or is inadequate, the rubber pellets will float around and redistribute themselves.

That's the Cliff Notes version.

I landscaped during the summer in college one job we had to dig 6" down with a pick ax through soil cement for about 50 yards to lay down some irrigation in 102 F ... The next semester I took 18 hours to get the hell out of school and find an office job.

[HOUCajun]

There are turf fields that put cork pellets down to reduce temps. I know they did at Nebraska. I seems to me they would float however.

[Frenchie35]

Don't thank me now, more to come: Not working today:

[Turbine]

Don't thank me now, more to come: Not working today:

That looks like big fat sandy exclamation point on a national championship season.

[CajunAmos]

Beat me to it Frenchie. I went by for lunch today and took a few as well.

Helmut, I tried to get some closer views of the edge of the concrete, the drain area, and the honeycomb forms that I saw. Below is the outfield gate area and the drain area by the fence. I still don't know where they are going to route the water once it leaves the drain.

[CajunAmos]

Below is the edge where the old turf, concrete, and dirt infield meet.

[CajunAmos]

Below is a far and closer view of the honeycomb forms I mentioned earlier.

[Frenchie35]

If we keep this up we will have our pick of the most elite in High School Softball. The will be knocking down out doors to come in.......

[CajunAmos]

Have you seen our commitments for the next three years?

[Frenchie35]

Where does that honeycomb go?

[CajunAmos]

Where does that honeycomb go?

I saw some underneath the concrete that they finished pouring by the right field gate yesterday. I'm assuming it was below all the concrete.